Photo: ©istockphoto.com/MCCAIG

Photo: ©istockphoto.com/MCCAIG

Ignoring fuel-savings strategies such as vehicle maintenance, driver training and route selection can reduce a vehicle’s cumulative fuel efficiency by about 45%, according to a study from the University of Michigan Transportation Research Institute (UMTRI).

Without any such strategies in place, the study found that a vehicle that should obtain 36 mpg will end up earning less than 20 (see table below). Fortunately, each of these factors are within a fleet manager’s and driver’s control.

Source: UMRTI 2011 study

Source: UMRTI 2011 study

The table shows how much efficient driving and other strategic fleet decisions can impact a vehicle’s fuel efficiency. This 36-mpg vehicle — one of the most efficient internal-combustion engine models in the U.S. at the time of the study — ends up getting only 19.8 mpg after calculating in excessive idling, route selection and other factors.

UMTRI’s analysts call these efficient driving strategies “eco-driving.” They break down the various factors that affect fuel efficiency by looking at three areas: operational decisions such as aggressive driving, tactical decisions like route selection, and strategic decisions such as vehicle maintenance.

Operational Decisions: Driving Behavior
Idling, low and high speeds, cruise control, air conditioning and aggressive driving all play a negative role on a vehicle’s fuel economy. Depending on engine size, idling uses a quarter- to a half-gallon of fuel per hour. While people are often under the impression that it’s better to idle for a minute or two rather than restart the vehicle, “it only takes a few seconds worth of fuel to restart your engine,” according to the Environmental Protection Agency (EPA).

Utilizing cruise control at highway speeds can improve fuel consumption by about 7%. Speed in general is like “an inverted U-shaped function” in terms of fuel efficiency, in which the lowest and highest speeds are the least ideal. For example, the study points out that a 2007 Honda Accord experienced its best fuel economy in a natural setting at 61 mph. Driving 30 mph below or above that speed resulted in at least a 30% decrease in fuel efficiency.[PAGEBREAK]

Turning on the air conditioner has been found to cause similar effects on fuel spend. It turns out that using the A/C can reduce mileage by as little as 5% and as much as 25%. While this is a wide range, the last component of operational decisions — aggressive driving — consistently affects fuel economy by an average of 31%. However, between the 10th and 90th percentile, the mpg achieved among drivers in the same vehicle varies by about 20%.

The table below breaks down each of the efficient driving strategies, which total for an average, cumulative effect on fuel efficiency by 45%.

Source: UMRTI 2011 study

Source: UMRTI 2011 study

Tactical Decisions: Route Management and Rightsizing
Do you choose the long, flat route or the shortcut through the hills? Would there really be a noticeable difference on fuel efficiency? According to the UMTRI study, in cases where two routes were taken to the same destination, the flat route resulted in a 15-20% improvement in fuel economy.

Heavy traffic is an even greater concern. Going from “free flow” traffic to “forced or breakdown flow” can reduce fuel efficiency by 20-40%. But the most significant drop occurs when traffic transitions from an “unstable flow” to the final category of a “forced or breakdown flow.” These traffic-level classifications suggest that light and medium traffic don’t affect fuel efficiency as much as gridlock.

In choosing the right vehicle for your business, be sure to select the best model variant for the job. The UMTRI study shows that the mean range for cars that have two or more model variants is 4.3 mpg, and 4.9 mpg for light-duty trucks. And while these ranges might not seem like much, that’s 18% of the average fuel economy of all vehicles. So, do you really need that crew cab?

Finally, think about what you actually need to carry in your vehicle for each trip. According to the EPA, for every 100 pounds added to a vehicle, fuel efficiency is reduced by up to 2%. UMTRI also estimates that the average U.S. adult weight-gain — about 24 pounds from 1960 to 2002 — has reduced the overall fuel economy by about half a percentage point.

Strategic Decisions: Vehicle Maintenance
Failing to properly maintain the engine, check the tires or use the correct engine oil can also hurt fuel efficiency. The study quotes a 2011 EPA study which found that “fixing a car that is noticeably out of tune or has failed an emission test can improve its gas mileage by an average of 4%, though results vary based on the kind of repair and how well it is done.” As well, the EPA says that fixing a faulty oxygen sensor can improve mileage “by as much as 40%.”

For every 1 psi drop in tire inflation, the vehicle’s fuel economy will drop an average of 0.3%. Using the wrong type of engine oil can decrease efficiency by 1-2%.

Reducing operational costs for your small business fleet requires a combination of driver training and route optimization. Achieving both will take time, but in the long run, making the most out of these decisions will definitely cost less than the gas you’re wasting.

About the author
Joanne Tucker

Joanne Tucker

Former Custom Media Manager

Joanne is a former custom media manager for Bobit Business Media.

View Bio
0 Comments