General Motors has announced six new recalls affecting more than 3.3 million vehicles, including late-model Chevrolet Silverado and GMC Sierra 2500/3500 HD trucks as well as Cadillac ATS and CTS sedans.
The June 16 truck recall affects 57,192 2015 model-year Chevrolet Silverado 2500/3500 HD and GMC Sierra 2500/3500 HD vehicles. Dealers will inspect for proper attachment of the power steering hose clamps to the power steering pump.
If the vehicle is driven with the clamp unattached, the hose may disconnect from the pump or gear, causing a rapid loss of power steering fluid. This will result in a sudden loss of power steering assist and Hydro Boost powered brakes. The vehicle would revert to manual brakes and manual steering.
GM said it knows of no crashes or injuries arising from the condition. Dealers will inspect the power steering hose clamps in two locations to ensure they are properly attached.
A second recall involves 68,887 2013-14 model-year Cadillac ATS sedans and 21,863 2014 model-year Cadillac CTS sedans. In certain vehicles with automatic transmission, the shift cable may not be fully secured to the shifter bracket or transmission bracket. If the shift cable comes out of the brackets, the driver may not be able to shift the transmission in or out of gear. GM said it is unaware of any crashes or injuries related to this condition.
The largest of the six recalls involves GM's plans to modify or replace the ignition keys for about 3.16 million cars in the U.S. because the ignition switch may inadvertently move out of the “run” position. This risk occurs if the key is carrying extra weight and is jostled.
The following cars are recalled:
Buick Regal LS & GS
Chevy Monte Carlo
The use of a key with a hole, rather than a slotted key, addresses the concern of unintended key rotation arising from a jarring road event, such as striking a pothole or crossing railroad tracks, GM said.
Only one of the models included in this U.S. recall of 3,160,725 cars is still in production – the previous-generation Chevrolet Impala. This model is sold to daily rental fleets as the Impala Limited. The total North America population – U.S., Canada, Mexico and exports – is 3,360,555.
This safety recall follows a review of ignition issues following the recall in February of 2.6 million Chevrolet Cobalts and other small cars. GM said it is aware of eight crashes and six injuries related to this recall.
If the ignition switch moves out of the “run” position, there is an effect on power steering and power braking. In addition, the timing of the key movement out of the “run” position, relative to the activation of the sensing algorithm of a crash event, may result in the air bags not deploying.
In these vehicles, the ignition switch may be unable to handle extra weight hanging on a slotted key. GM will add an insert to the ignition keys to close the slot and leave a 4x6-millimeter hole through which the key ring could be attached.
In vehicles where the key cover has been worn, new keys with holes instead of slots will be provided free of charge.
Rework of the keys – adding key inserts – at GM dealerships is expected to begin in the next few weeks. Until the rework or replacement is completed, owners of the recalled cars are urged to remove additional weight from their key chains and drive with only the ignition key.
A fourth recall covers 184 2014-15 model-year Chevrolet Silverado and GMC Sierra full-size pickups with vinyl floors and accessory all-weather floor mats purchased new with the vehicle. The mats can slip under the driver’s feet because the vinyl floors have no attachments to secure them in place.
Customers are advised to take the floor mats to their dealer for a full refund. GM said it is unaware of any crashes or injuries related to the mats.
A fifth recall covers 16,932 2011 model-year Cadillac CTS sedans with AWD. On some vehicles, a gasket leak where the constant velocity joint meets the rear propeller shaft may cause the rear propeller shaft to separate or become loose. This can lead to contact with the vehicle floor above and cause the rollover sensor to deploy the roof rail air bags. GM said it is aware of 15 unintended deployments, but injury data is unclear.
The sixth recall involves 712 2014 model-year Chevrolet Corvettes with optional Competition Sport Seats. An unbelted child and door trim may block the passenger-seat side air bag vent in a deployment. Dealers will replace the current air bag with a redesigned version. GM said it is unaware of any crashes or injuries related to this condition, but advises customers to not allow small children in the front seat until the vehicle is serviced.
Originally posted on Automotive Fleet